Need to diagnose problem
I posted this on the Bicycle Mechanics forum here but it’s quickly scrolling down the page so I’ll try here:
I own a 2017 Specialized Roubaix SL4 Sport which I bought NOS earlier this year. It uses the 105 5800 11speed with 11-32t derailleurs and shifters and Praxis cranks and BB. I’m having an issue with a sporadic clicking sound when pedaling. It doesn’t seem to be related to the gear I’m in and I just had the dealer adjust the derailleurs. They shift perfectly and there’s no chain rub. Any thoughts on where this clicking is coming from? |
Check the end cable on your FD. Sometimes it sticks out and hits your pedal or your shoe. Tighten your seat post. Tighten your skewers. Check your bottom bracket.
|
Along with the above, double check pedal to crank interface. Light coat of lubricant, and tight.
|
Thank you. Pedals are tight, it’s not the cable or seatpost. Definitely not the skewers. The sound is coming from the pedal area. How do I check the BB? If it’s that, I’d take it under warranty to the dealer. My suspicion is it’s the BB.
|
Also check your chainring and crank spider hardware, to be sure they're tight.
|
Often “creaking” noises can be difficult to isolate due to the tendency of sounds to resonate through carbon frames. However, if it is the BB, you should be able to confirm that on a maintenance stand or perhaps in a quiet corner on a shop floor. Try twisting the cranks and pulling and pushing them side to side. There should be no play at all. Any play or noises probably indicate the bearings need attention. Could be dry, corroded, dirty, loose, infiltrated by water, or a combination of issues. It’s also remotely possible that the crank arm could come loose from the axle, which would need replacing. My Praxis BB needed cleaning and repacking at about one year. Praxis recommends yearly BB maintenance anyway. You definitely should be able to get the BB fixed under warranty.
Good luck! |
If it’s a faint ticking noise, check that the ends of your shoelaces aren’t slapping the crank. I had that happen once.
|
Originally Posted by MattTheHat
(Post 21088056)
If it’s a faint ticking noise, check that the ends of your shoelaces aren’t slapping the crank. I had that happen once.
|
If you have clipless pedals, check the cleats. Sometimes they loosen. Also, even though you think it's coming from bottom bracket area, check stem, headset and brifter bolts.
|
Originally Posted by MonsterFat
(Post 21088097)
If you have clipless pedals, check the cleats. Sometimes they loosen. Also, even though you think it's coming from bottom bracket area, check stem, headset and brifter bolts.
|
Is it a single click or a series?
Is it timelocked to the pedal stroke or variable? Is it load dependent, and if so, is it with load on one side or both? I probably won’t have any useful ideas, but these are essential questions. |
Originally Posted by MoAlpha
(Post 21088127)
Is it a single click or a series?
Is it timelocked to the pedal stroke or variable? Is it load dependent, and if so, is it with load on one side or both? I probably won’t have any useful ideas, but these are essential questions. |
Have you checked the torque on the Praxis cranks? The Praxis cranks on my Diverge weren’t tightened to spec (too loose) which also caused some creaking.
|
Originally Posted by tagaproject6
(Post 21087912)
Check the end cable on your FD. Sometimes it sticks out and hits your pedal or your shoe.
|
Originally Posted by MSchott
(Post 21088186)
Its a few clicks per revolution, it’s not really load dependent but if I focus on a smooth stroke it seems to lessen but not go away. It’s variable to the pedal stroke.
|
Just a random thought as it happened to me...
If you have nuts on the valve stems to hold them in place, make sure they're tight. I had a clicking noise once/twice per revolution that was coming from "somewhere" down and behind my ears. Took 15 minutes on the stand in super quiet garage to locate it. Felt like a tool once I realized how simple it was. A little blue loctite and away I quietly went. |
Originally Posted by TheGBKid
(Post 21088784)
Just a random thought as it happened to me...
If you have nuts on the valve stems to hold them in place, make sure they're tight. I had a clicking noise once/twice per revolution that was coming from "somewhere" down and behind my ears. Took 15 minutes on the stand in super quiet garage to locate it. Felt like a tool once I realized how simple it was. A little blue loctite and away I quietly went. |
Originally Posted by MSchott
(Post 21088186)
Its a few clicks per revolution, it’s not really load dependent but if I focus on a smooth stroke it seems to lessen but not go away. It’s variable to the pedal stroke.
|
Take the cranks off and lube everything in the bb, or have someone do it for you.
|
Originally Posted by MattTheHat
(Post 21088056)
If it’s a faint ticking noise, check that the ends of your shoelaces aren’t slapping the crank. I had that happen once.
|
Originally Posted by Kimmo
(Post 21089687)
Sounds like maybe seat or seatpost. How much post is in the seat tube? If it extends far below the clamp, trimming it might do the trick.
|
Originally Posted by MSchott
(Post 21089827)
Its the OEM seatpost on a frame properly sized for me. I doubt it’s that.
|
I typically recommend doing one leg pedaling (disconnecting one foot from the other pedal completely), then swapping legs. This might at least tell you it's a pedal/cleat vs BB thing.
|
Here’s an update. I followed most of your suggestions. Tightened the cleats, lubed and tightened the pedals, chainrings and other driveline components. Made sure the FD cable was out of the way. Checked the seatpost and more.
Problem is is still there. It doesn’t show until after about 10 miles but it’s still there. It’s more prominent under heavier load and relatedly up hills. The sound is between a creak and a click and is worse as the load increases like in the big ring, 13 tooth sprocket. Any more thoughts? |
That's usually spoke crossings. PITA but no harm.
|
All times are GMT -6. The time now is 12:51 PM. |
Copyright © 2024 MH Sub I, LLC dba Internet Brands. All rights reserved. Use of this site indicates your consent to the Terms of Use.