Cygolite battery replacement
#26
Senior Member
Join Date: Jun 2009
Location: Silicon Valley, CA
Posts: 3,209
Mentioned: 2 Post(s)
Tagged: 0 Thread(s)
Quoted: 139 Post(s)
Liked 33 Times
in
20 Posts
For best LiIon life: Use until about 50% discharged and wait just before use to recharge. I approximate this as best as reasonable with my stuff and don't sweat it too much. e.g. My f/r blinkies have about 7 hrs of life. I might do two rides totaling ~4 hrs, then charge them up the morning of (or night before) the third ride. I usually don't charge the Garmin until it's about 1/2 down. Same with my phone.
How to Prolong Lithium-based Batteries - Battery University
#28
Let's Ride!
Join Date: Jul 2008
Location: Triad, NC USA
Posts: 2,569
Bikes: --2010 Jamis 650b1-- 2016 Cervelo R2-- 2018 Salsa Journeyman 650B
Mentioned: 22 Post(s)
Tagged: 0 Thread(s)
Quoted: 327 Post(s)
Liked 37 Times
in
24 Posts
when Cygolite says that there is a low battery indicator what does it mean? I have yet to figure it out on my HOtshot?
#29
Senior Member
#30
Let's Ride!
Join Date: Jul 2008
Location: Triad, NC USA
Posts: 2,569
Bikes: --2010 Jamis 650b1-- 2016 Cervelo R2-- 2018 Salsa Journeyman 650B
Mentioned: 22 Post(s)
Tagged: 0 Thread(s)
Quoted: 327 Post(s)
Liked 37 Times
in
24 Posts
#34
Senior Member
Join Date: Apr 2012
Location: Memphis TN area
Posts: 7,391
Bikes: 2011 Felt Z85 (road/commuter), 2006 Marin Pine Mountain (utility/commuter E-bike), 1995 KHS Alite 1000 (gravel grinder)
Mentioned: 25 Post(s)
Tagged: 0 Thread(s)
Quoted: 676 Post(s)
Likes: 0
Liked 13 Times
in
13 Posts
The Expilion front light will start to flicker the light inside the power button when the battery gets low. The amount of flicker/flash increases as the battery gets lower, and the light output also reduces. I have run my Expilion 700 low many times, and completely dead a few times.
I have not noticed any apparent loss in battery life on any of the lights yet, and they are now entering their 3rd fall/winter season.
#36
aka Tom Reingold
Thread Starter
Join Date: Jan 2009
Location: New York, NY, and High Falls, NY, USA
Posts: 40,591
Bikes: 1962 Rudge Sports, 1971 Raleigh Super Course, 1971 Raleigh Pro Track, 1974 Raleigh International, 1975 Viscount Fixie, 1982 McLean, 1996 Lemond (Ti), 2002 Burley Zydeco tandem
Mentioned: 513 Post(s)
Tagged: 0 Thread(s)
Quoted: 7397 Post(s)
Liked 2,571 Times
in
1,498 Posts
I forgot to follow up. Cygolite said they would charge me $5 or $10 to replace the battery, but instead, they sent me a whole new light, complete in the package with mount and cable and everything, even though I didn't send everything back to them as they had requested. I had lost some of the pieces. Anyway, I consider this to be very good customer service. Cygolite seems like a good company, and it sure doesn't hurt that they make their stuff right here in the US. Imagine that! They make good stuff at good prices and figure out how to do it domestically.
__________________
Tom Reingold, tom@noglider.com
New York City and High Falls, NY
Blogs: The Experienced Cyclist; noglider's ride blog
“When man invented the bicycle he reached the peak of his attainments.” — Elizabeth West, US author
Please email me rather than PM'ing me. Thanks.
Tom Reingold, tom@noglider.com
New York City and High Falls, NY
Blogs: The Experienced Cyclist; noglider's ride blog
“When man invented the bicycle he reached the peak of his attainments.” — Elizabeth West, US author
Please email me rather than PM'ing me. Thanks.
#37
Randomhead
Join Date: Aug 2008
Location: Happy Valley, Pennsylvania
Posts: 24,489
Mentioned: 0 Post(s)
Tagged: 0 Thread(s)
Quoted: 4 Post(s)
Liked 3,791 Times
in
2,582 Posts
#39
Senior Member
Join Date: Jan 2016
Location: 961' 42.28° N, 83.78° W (A2)
Posts: 2,344
Bikes: Mongoose Selous, Trek DS
Mentioned: 8 Post(s)
Tagged: 0 Thread(s)
Quoted: 941 Post(s)
Liked 319 Times
in
189 Posts
Seemed like a thread in which to insert this. I don't ride at night, so my use for lights to be seen so I use the first blink function, not necessarily to see. I have a Cygolite (Metro) headlight and the Cygolite Hotshot taillight. Use them on every ride regardless of whether it is sunny or overcast. I generally throw them on the charger after each ride, or every other ride. Today, after a one hour ride, decided to just let them go and see how long they last. The headlight completely died at 7 hours, I would give it 6 hours of good visibility and function. The taillight, well it is still on, and its been 8 hours! Just an FYI and I have no connection to the manufacturer.
#40
Senior Member
Join Date: Apr 2012
Location: Memphis TN area
Posts: 7,391
Bikes: 2011 Felt Z85 (road/commuter), 2006 Marin Pine Mountain (utility/commuter E-bike), 1995 KHS Alite 1000 (gravel grinder)
Mentioned: 25 Post(s)
Tagged: 0 Thread(s)
Quoted: 676 Post(s)
Likes: 0
Liked 13 Times
in
13 Posts
Seemed like a thread in which to insert this. I don't ride at night, so my use for lights to be seen so I use the first blink function, not necessarily to see. I have a Cygolite (Metro) headlight and the Cygolite Hotshot taillight. Use them on every ride regardless of whether it is sunny or overcast. I generally throw them on the charger after each ride, or every other ride. Today, after a one hour ride, decided to just let them go and see how long they last. The headlight completely died at 7 hours, I would give it 6 hours of good visibility and function. The taillight, well it is still on, and its been 8 hours! Just an FYI and I have no connection to the manufacturer.
On your Metro does it have the daytime flash function? On mine I press and hold the power button when first turning it on, and it switches to a mode where it stays off for a second then flashes 3 bright flashes at full power, then off for a second, then 3 flashes, and so on. I like it because the battery will last me a week or more when I use that mode only, but the flashes are still full brightness.
#41
Senior Member
Join Date: Jan 2016
Location: 961' 42.28° N, 83.78° W (A2)
Posts: 2,344
Bikes: Mongoose Selous, Trek DS
Mentioned: 8 Post(s)
Tagged: 0 Thread(s)
Quoted: 941 Post(s)
Liked 319 Times
in
189 Posts
Hmm, don't know about the initial press and hold first thing. I'll try it when recharged. I did not sense any heat issue when I did the test. It was a steady blinking with on and off time seeming equal. The pattern you describe does sound like it would last longer.
#42
Senior Member
Join Date: Apr 2012
Location: Memphis TN area
Posts: 7,391
Bikes: 2011 Felt Z85 (road/commuter), 2006 Marin Pine Mountain (utility/commuter E-bike), 1995 KHS Alite 1000 (gravel grinder)
Mentioned: 25 Post(s)
Tagged: 0 Thread(s)
Quoted: 676 Post(s)
Likes: 0
Liked 13 Times
in
13 Posts
Oh that must be a different flash pattern specific to the Metro.
*edit* I looked at the Cygolite website. On Expilion lights, the DayFlash mode I described above is a "special" mode that is accessed by pressing and holding the power button. On the Metro lights, DayFlash is one of the normal modes that you get to by just going through the modes - it's after the SteadyPulse mode that's meant to be used at night (keeps the light on and pulsates every couple of seconds). If you press and hold the button you get to the one special mode for walking, which is lower than the lowest regular setting.
*edit* I looked at the Cygolite website. On Expilion lights, the DayFlash mode I described above is a "special" mode that is accessed by pressing and holding the power button. On the Metro lights, DayFlash is one of the normal modes that you get to by just going through the modes - it's after the SteadyPulse mode that's meant to be used at night (keeps the light on and pulsates every couple of seconds). If you press and hold the button you get to the one special mode for walking, which is lower than the lowest regular setting.
Last edited by PatrickGSR94; 03-18-16 at 07:58 PM.
#43
Senior Member
LiIon is 4.2 volts. You can't get a protected battery to discharge to that low a voltage! Battery University has good info on prolonging battery life for many different battery chemistries.
How to Prolong Lithium-based Batteries - Battery University
How to Prolong Lithium-based Batteries - Battery University
For best LiIon life: Use until about 50% discharged and wait just before use to recharge. I approximate this as best as reasonable with my stuff and don't sweat it too much...
Anyway, before you start suggesting that he ( or someone else ) read up at Battery University you might want to do some more reading yourself. Not trying to make you look stupid, but since Looigi didn't explain what he meant I felt it needed to be clarified so someone else doesn't assume the same thing.
#44
Newbie
Join Date: Mar 2024
Posts: 1
Mentioned: 0 Post(s)
Tagged: 0 Thread(s)
Quoted: 1 Post(s)
Likes: 0
Liked 0 Times
in
0 Posts
Li-ion batteries need to be charged at a several times year.
My Cygolite Hotshot (tail light) is two or three years old, and the battery no longer holds a charge. I contacted the company from their web page, and a person named Paul from the company said I could return it for battery replacement. I'm willing to pay, but he hasn't yet told me if I have to or how much it will be. So far, so good. This is the normal lifespan of a LiIon battery, so I'm not complaining.
#45
aka Tom Reingold
Thread Starter
Join Date: Jan 2009
Location: New York, NY, and High Falls, NY, USA
Posts: 40,591
Bikes: 1962 Rudge Sports, 1971 Raleigh Super Course, 1971 Raleigh Pro Track, 1974 Raleigh International, 1975 Viscount Fixie, 1982 McLean, 1996 Lemond (Ti), 2002 Burley Zydeco tandem
Mentioned: 513 Post(s)
Tagged: 0 Thread(s)
Quoted: 7397 Post(s)
Liked 2,571 Times
in
1,498 Posts
If I remember right, that's not what happened to me. I didn't let the battery discharge. The battery just lost its ability to hold a charge, and it happened prematurely. But these things happen. Rather than replace the battery, the company replaced the whole light, and with it, I got new mounts, which came in handy. I'm impressed with the quality and service from Cygolite. I also like the fact that they make their stuff here in the US. We have to expect a few defects here and there, and service compensated for that. By the way, welcome to bikeforums.
__________________
Tom Reingold, tom@noglider.com
New York City and High Falls, NY
Blogs: The Experienced Cyclist; noglider's ride blog
“When man invented the bicycle he reached the peak of his attainments.” — Elizabeth West, US author
Please email me rather than PM'ing me. Thanks.
Tom Reingold, tom@noglider.com
New York City and High Falls, NY
Blogs: The Experienced Cyclist; noglider's ride blog
“When man invented the bicycle he reached the peak of his attainments.” — Elizabeth West, US author
Please email me rather than PM'ing me. Thanks.
Likes For noglider:
Thread
Thread Starter
Forum
Replies
Last Post
libove
Electronics, Lighting, & Gadgets
18
10-21-15 01:40 PM
robmcl
Electronics, Lighting, & Gadgets
4
12-06-13 09:53 PM
Spld cyclist
Electronics, Lighting, & Gadgets
3
11-28-11 04:10 PM
Barrettscv
Commuting
17
10-18-11 08:01 AM