Rim Tape?
#1
Junior Member
Thread Starter
Join Date: May 2009
Posts: 90
Mentioned: 0 Post(s)
Tagged: 0 Thread(s)
Quoted: 1 Post(s)
Likes: 0
Liked 1 Time
in
1 Post
Rim Tape?
Living in South Africa for the past few years. Last year I bought a Trek 7300 with two wheelsets. The narrower tires didn't hold pressure well, so I swapped out the the set with 32mm tires.
I then stripped the tires off the narrow wheelset, and hard pieces of rim liner fell out. I guess this is what had caused the previous issues.
Rim tape at the local bike shop is only available in bigger (more expensive rolls), else they will charge to retape.
I am moving to a smaller country town where access to well-stocked cycle shops is slightly more problematic. What would make a 'reasonable' (not perfect) and cost effective substitute? I have taped the rim with electrical tape for now, but suspect I may need at least 2 layers. The other alternative is maybe cloth wiring / electrical tape, which should be available in the hardware store.
Or am I being naive and have to go online and pay shipping charges (and wait) for the 'real thing'?
I then stripped the tires off the narrow wheelset, and hard pieces of rim liner fell out. I guess this is what had caused the previous issues.
Rim tape at the local bike shop is only available in bigger (more expensive rolls), else they will charge to retape.
I am moving to a smaller country town where access to well-stocked cycle shops is slightly more problematic. What would make a 'reasonable' (not perfect) and cost effective substitute? I have taped the rim with electrical tape for now, but suspect I may need at least 2 layers. The other alternative is maybe cloth wiring / electrical tape, which should be available in the hardware store.
Or am I being naive and have to go online and pay shipping charges (and wait) for the 'real thing'?
#2
Senior Member
Join Date: Oct 2008
Location: Right where I'm supposed to be
Posts: 1,634
Bikes: Franklin Frames Custom, Rivendell Bombadil
Mentioned: 2 Post(s)
Tagged: 0 Thread(s)
Quoted: 117 Post(s)
Liked 209 Times
in
127 Posts
Shipping/strapping filament tape works just fine and comes in various widths. Here's a 3M page which gives you an idea of what may be available in your country. I've had it on a set of rims for years and it just works.
https://www.3m.com/3M/en_US/p/c/tapes/filament/
https://www.3m.com/3M/en_US/p/c/tapes/filament/
Likes For Garthr:
#3
Senior Member
Join Date: Nov 2014
Location: Eugene, Oregon, USA
Posts: 27,547
Mentioned: 217 Post(s)
Tagged: 0 Thread(s)
Quoted: 18378 Post(s)
Liked 4,512 Times
in
3,354 Posts
I've tried cloth electrical tape, but I think it often is sticky on both sides and makes a bit of a mess.
Do you have single walled or double walled rims? The tape requirements may be different for the two, as the single walled rims just needs one to cover the nipples, and the double walled rims need support over the holes.
Cloth handlebar tape may also substitute for rim tape, but probably isn't any cheaper than the rim tape.
With newer tighter fitting tires/rims, I've pretty much given up on the cloth tapes, and started getting plastic rim tapes. Usually ordering a few from overseas bike shops.
I have intended to experiment with various heavy duty tapes, like packing tape, but ultimately it wasn't needed.
Do you have single walled or double walled rims? The tape requirements may be different for the two, as the single walled rims just needs one to cover the nipples, and the double walled rims need support over the holes.
Cloth handlebar tape may also substitute for rim tape, but probably isn't any cheaper than the rim tape.
With newer tighter fitting tires/rims, I've pretty much given up on the cloth tapes, and started getting plastic rim tapes. Usually ordering a few from overseas bike shops.
I have intended to experiment with various heavy duty tapes, like packing tape, but ultimately it wasn't needed.
#4
señor miembro
Join Date: Dec 2018
Location: Pac NW
Posts: 6,627
Bikes: '70s - '80s Campagnolo
Mentioned: 92 Post(s)
Tagged: 0 Thread(s)
Quoted: 3890 Post(s)
Liked 6,491 Times
in
3,213 Posts
Likes For SurferRosa:
#5
Friendship is Magic
Join Date: Nov 2010
Location: Sacramento, CA
Posts: 22,985
Bikes: old ones
Mentioned: 304 Post(s)
Tagged: 0 Thread(s)
Quoted: 26425 Post(s)
Liked 10,381 Times
in
7,209 Posts
I usually use a couple of full wraps of Kapton tape. It's tough, so use something like an ice pick to punch the valve stem hole.
__________________
Likes For 3alarmer:
#6
señor miembro
Join Date: Dec 2018
Location: Pac NW
Posts: 6,627
Bikes: '70s - '80s Campagnolo
Mentioned: 92 Post(s)
Tagged: 0 Thread(s)
Quoted: 3890 Post(s)
Liked 6,491 Times
in
3,213 Posts
#7
Senior Member
Join Date: Jul 2015
Location: NW Oregon
Posts: 2,975
Bikes: !982 Trek 930R Custom, Diamondback ascent with SERIOUS updates, Fuji Team Pro CF and a '09 Comencal Meta 5.5
Mentioned: 15 Post(s)
Tagged: 1 Thread(s)
Quoted: 1299 Post(s)
Liked 739 Times
in
534 Posts
#8
Senior Member
Join Date: Apr 2009
Location: New Rochelle, NY
Posts: 38,727
Bikes: too many bikes from 1967 10s (5x2)Frejus to a Sumitomo Ti/Chorus aluminum 10s (10x2), plus one non-susp mtn bike I use as my commuter
Mentioned: 140 Post(s)
Tagged: 1 Thread(s)
Quoted: 5793 Post(s)
Liked 2,590 Times
in
1,436 Posts
My old standby is cloth surgical (first aid) tape. Though the cloth version is getting scarcer as plastic is taking over, it's still available at most retail drug stores. A roll is cheap enough, and any left over can be kept and used with your other first aid supplies, so no waste.
__________________
FB
Chain-L site
An ounce of diagnosis is worth a pound of cure.
Just because I'm tired of arguing, doesn't mean you're right.
“One accurate measurement is worth a thousand expert opinions” - Adm Grace Murray Hopper - USN
WARNING, I'm from New York. Thin skinned people should maintain safe distance.
FB
Chain-L site
An ounce of diagnosis is worth a pound of cure.
Just because I'm tired of arguing, doesn't mean you're right.
“One accurate measurement is worth a thousand expert opinions” - Adm Grace Murray Hopper - USN
WARNING, I'm from New York. Thin skinned people should maintain safe distance.
#9
Senior Member
Join Date: Jul 2005
Location: Boulder County, CO
Posts: 4,398
Bikes: '80 Masi Gran Criterium, '12 Trek Madone, early '60s Frejus track
Mentioned: 6 Post(s)
Tagged: 0 Thread(s)
Quoted: 514 Post(s)
Liked 451 Times
in
339 Posts
Gorilla Tape, if you can get it. Also, the cheap rubber rim strips most shops sell for about a dollar work fine as long as your pressures are below 80 psi (5.3 atm).
#10
Sr Member on Sr bikes
+1 on the Kapton tape.
Dan
Dan
Likes For _ForceD_:
#11
Senior Member
Join Date: Jul 2014
Posts: 1,490
Mentioned: 2 Post(s)
Tagged: 0 Thread(s)
Quoted: 1083 Post(s)
Liked 687 Times
in
441 Posts
I wouldn't ride with electrical tape in there for very long. Even with two layers, it's still going to move around and create a sticky mess. I've done it in an emergency (two layers) but replaced it as soon as I could.
If you have to order something, why not just go with Velox? You're not going to find anything better - it lasts forever and doesn't move. Plus it's available in a number of different widths.
If you have to order something, why not just go with Velox? You're not going to find anything better - it lasts forever and doesn't move. Plus it's available in a number of different widths.
Likes For Jeff Neese:
#12
Keefusb
Join Date: Jan 2021
Location: Ashland, VA
Posts: 176
Bikes: 60cm 1992 Paramount, 60cm 1995 Cannondale R900 (son's bike), 1994 Cannondale H300 (mine), 1994 Cannondale H300 Killer V (wife's bike), 60 cm 1989 Eddy Merckx Corsa Extra SLX
Mentioned: 0 Post(s)
Tagged: 0 Thread(s)
Quoted: 83 Post(s)
Liked 57 Times
in
36 Posts
Velox or Pedro's rim tape would be my first choice. In a pinch, fiber-reinforced packing tape, or cloth first aid tape will work, but I have found that the first aid tape leaves a sticky mess like electrical tape. You can order Velox or Pedro's rim tape from most reputable online bike parts sources or Amazon. REI retail brick and mortar stores usually carry them as well.
#13
Full Member
I'm looking for an alternative to Velox which isn't working for me though it has worked fine on other rims for years. I need tape that sits in the "well" of this rim so it doesn't interfere with with the tire seating properly. The rim is H Plus Son Hydra. I had a bike that had yellow "shiny" tape that was wrapped twice around the rim but don't know what it was. Any ideas for tape that won't slip or what that yellow rim tape might have been?
#14
Senior Member
Join Date: Oct 2013
Location: Mich
Posts: 7,397
Bikes: RSO E-tire dropper fixie brifter
Mentioned: 0 Post(s)
Tagged: 0 Thread(s)
Quoted: 6 Post(s)
Liked 2,980 Times
in
1,921 Posts
are plugging the holes prior to applying the tape?
__________________
-Oh Hey!
-Oh Hey!
Likes For Troul:
#16
Full Member
#17
Senior Member
Join Date: Feb 2012
Location: Golden, CO and Tucson, AZ
Posts: 2,837
Bikes: 2012 Specialized Elite Disc, 1983 Trek 520
Mentioned: 13 Post(s)
Tagged: 0 Thread(s)
Quoted: 676 Post(s)
Liked 741 Times
in
430 Posts
I'm looking for an alternative to Velox which isn't working for me though it has worked fine on other rims for years. I need tape that sits in the "well" of this rim so it doesn't interfere with with the tire seating properly. The rim is H Plus Son Hydra. I had a bike that had yellow "shiny" tape that was wrapped twice around the rim but don't know what it was. Any ideas for tape that won't slip or what that yellow rim tape might have been?
Spoke holes can be plugged with Veloplugs in lieu of tape. I just tried them for the first time last month and they seem to be fine, but they do add diameter making tires harder to mount. That's the main reason I normally use Stans or Kapton.
Likes For andrewclaus:
Likes For easyupbug:
#19
Senior Member
Join Date: Jan 2009
Location: San Diego, CA
Posts: 3,677
Mentioned: 10 Post(s)
Tagged: 0 Thread(s)
Quoted: 839 Post(s)
Liked 1,064 Times
in
747 Posts
Likes For Crankycrank:
#20
Senior Member
Join Date: Oct 2013
Location: Mich
Posts: 7,397
Bikes: RSO E-tire dropper fixie brifter
Mentioned: 0 Post(s)
Tagged: 0 Thread(s)
Quoted: 6 Post(s)
Liked 2,980 Times
in
1,921 Posts
if leaking with just one of the options stills occurs, try dabbing the plugs in an anaerobic sealant & using tubeless specific rim tape that crowds the least of the inner rim area.
__________________
-Oh Hey!
-Oh Hey!
#21
Senior Member
Join Date: Dec 2020
Location: Wake Forest, NC
Posts: 5,795
Bikes: 1989 Cinelli Supercorsa
Mentioned: 11 Post(s)
Tagged: 0 Thread(s)
Quoted: 3514 Post(s)
Liked 2,927 Times
in
1,776 Posts
Why anyone would use anything other than Velox is beyond me.
#22
Full Member
#23
Senior Member
Join Date: Dec 2020
Location: Wake Forest, NC
Posts: 5,795
Bikes: 1989 Cinelli Supercorsa
Mentioned: 11 Post(s)
Tagged: 0 Thread(s)
Quoted: 3514 Post(s)
Liked 2,927 Times
in
1,776 Posts